Tesla is issuing a voluntary recall of the Model X before the government can whip out its red pen. The company claims a small percentage of SUVs suffer from a manufacturing defect that could prevent the rear seats from locking into place securely.

The risk comes in the event of a crash, when the center row — and those occupying it — could become projectiles aimed squarely at the back of the driver’s seat. (Read More…)

On Thursday, a U.S. judge dismissed the criminal charges against Toyota Motor Corp after the automaker completed a mandated three years of probationary monitoring. As part of its $1.2 billion settlement, where it admitted to intentionally misleading the public over dangerous unintended acceleration and building vehicles with faulty parts, Toyota was assigned former U.S. attorney David Kelley as an independent safety monitor.

“It is a long road ahead,” he said upon his appointment in 2014. “If you look at the deferred prosecution agreement there is a lot of ground to cover.”

The agreement gave Kelley sweeping powers to hire staff and review all of Toyota’s policies and operating procedures for communicating safety issues internally and to regulators. Kelley and his staff were required to be payed standard consulting fees and rates by Toyota, but this will be their last week on the job. (Read More…)

Automobiles are more tech-laden than ever and, according to a recent study, those interactive bells and whistles contribute heavily to distracted driving.

With connected cars ready to shoot off assembly lines and into driveways at an accelerated pace, the danger of someone flicking through their dashboard menus when they should be looking at the road is only going to grow. Many states prohibit phone usage while driving, yet there is no law against setting your radio pre-tunes or customizing your digital dashboard while hurtling down the expressway — not that there necessarily should be.

However, the American Automobile Association’s Foundation for Traffic Safety commissioned researchers from the University of Utah to examine the physical and mental demand required to complete various tasks using the infotainment systems in 30 new 2017 vehicles. The conclusion was that the growing cavalcade of buttons, screens, and technology does an incredibly good job at keeping you from minding the road ahead.  (Read More…)

Well, it might if a news crew profiles your SUV. A Maryland couple’s 2016 Ford Explorer, one of many late-model Explorers suspected of emitting high levels of carbon monoxide into the cabin, turned out to be doing just that. However, even after the exhaust leak was confirmed — then fixed — by Ford, peace of mind did not return to Mark and Valentina Shedrick.

With an NBC news team sniffing around and a National Highway Traffic Safety Administration investigation ongoing, the automaker decided to buy back the vehicle. Other owners, including police departments, would likely prefer knowing their vehicle is safe. (Read More…)

This week, the Coalition for Future Mobility — a recently formed automotive trade group representing major automakers and self-driving advocates — will roll out a bevy of targeted television spots, print ads, and social media posts specifically designed to encourage Congress to adopt legislation assisting the budding industry’s growth.

Earlier in the month, the House of Representatives passed a bill that would expedite the deployment of self-driving cars and prohibit states from blocking autonomous vehicle testing. This was immediately followed by Transportation Secretary Elaine Chao publicly outlining the NHTSA’s updated automotive safety guidance — which was less about ensuring the safe development of self-driving cars and more about destroying regulatory red tape.

The Senate is the final piece of the puzzle. Automakers want to make sure it’s seeing things their way before casting their vote on whether or not the industry gets the governmental green light.  (Read More…)

If you’ve been reading this site for a while, you might recall the incident nearly four years ago when your humble author managed to collect a Hyundai Sonata in the B-pillar. Both I and the woman in the front passenger seat were nontrivially injured in the crash, but the months and years of pain and surgery afterwards were made considerably easier to bear by the fact that my son, who was sitting in the right rear seat, escaped injury. I cannot tell you what I would have done or how I would have felt if he had been injured or killed.

Five months ago, a woman in Albuquerque made a left-hand turn across a busy urban intersection. As she did so, her Ford Escape was struck by a police car traveling at nearly 70 miles per hour. The six-year-old boy in the right rear seat was killed.

After a comprehensive investigation, the county sheriff has recommended that no charges be filed against either the driver of the Ford Escape or the officer who struck the vehicle. Their rationale for that recommendation is easy to see and there’s no reason to Monday-morning quarterback a crash with a result this tragic. We should, however, be talking about the circumstances that made that crash not only possible but likely.

(Read More…)

We all know minivans bring out a driver’s inner beast. Here at TTAC, hardly a day goes by where we’re not discussing which minivan is best suited for an impromptu spin around the track. Seriously.

However, if exploring the limits of your minivan’s handling abilities tops your short list of things to do today, Chrysler Pacifica drivers had best hold off — at least if you’ve got a crowded backseat. Fiat Chrysler Automobiles doesn’t want owners driving aggressively until they’ve taken their van in for a voluntary recall. (Read More…)

Occupational hazards exist in every industry, and we used to adhere to the notion of “acceptable losses” for certain projects. Over 20,000 people are estimated to have died under the French leadership of the Panama Canal’s construction, and another 6,000 when the Americans finally finished it in 1914 — two years ahead of its target date. Fifteen years later, five men perished during the construction of the Empire State Building, which was pretty good for the time.

However, acceptable workplace-related deaths aren’t really in style anymore. One causality is too many in today’s post-OSHA world, whether you’re in the U.S. or living beyond its borders. Such was the case two years ago when a robot crushed a 22-year-old man to death at a Volkswagen assembly plant. As a result, VW and other automakers are closely watching the efforts of Germany’s Institute of Robotics and Mechatronics in order to build a safer robot.  (Read More…)

It’s the same safety issue that saddled Ford’s Pinto with a notorious legacy that continues to this day, and Jeep can’t seem to put it in its rear-view.

In 2013, at the urging of the National Highway Traffic Safety Administration, Fiat Chrysler Automobiles issued a recall for 1.56 million Jeep Liberty and Grand Cherokee SUVs to correct a serious flaw. The vehicles’ gas tanks, located between the rear axle and bumper, had proven especially vulnerable to rupturing in rear-end collisions. A total of 26 deaths were recorded at the time of the recall.

After installing trailer hitches on each affected vehicle, FCA felt it had the issue well in hand. Unfortunately, the fires continued, as did the deaths. Now, it’s happened again. (Read More…)

Ford Motor Company finds itself on the receiving end of a lawsuit concerning the simplest part of any car or truck: the lug nuts.

In this case, nuts that swell and delaminate not long after purchase, rendering the vehicle’s lug wrench useless in the event of a flat tire, or when the owners decide to swap their seasonal rubber. The lawsuit, filed by Hagens Berman Thursday in the U.S. District Court for the Eastern District of Michigan, seeks class-action status. Hundreds of claimants have put their name to the suit.

Millions of Ford vehicles dating back to 2010, including the popular Fusion and F-150, feature two-piece lug nuts with a steel core and chrome, aluminum, or stainless cap for appearance purposes, the lawsuit claims. That outer cap can swell, potentially endangering owners’ lives and wallets. (Read More…)

Dodge is recalling Charger and Challenger Hellcats due to faulty engine oil cooler lines which may result in a rapid, catastrophic loss of fluids. The National Highway Traffic Safety Administration filed a recall request earlier this month, saying 1,207 vehicles assembled between February and May of 2017 may be affected.

According to the recall information, the issue stems from rubber used in the oil cooler line. Chrysler’s testing revealed that the rubber doesn’t meet the company’s usual criteria. Substandard materials can allow the hose to separate from a crimped aluminum portion of the line, letting oil gush out as if someone unscrewed a drain plug. (Read More…)

When the automobile came into its own, there wasn’t really a place for it. Roads had been reserved for foot traffic and horses for hundreds of years before the invention of the internal combustion engines. Pedestrian injuries were high until they were partitioned onto the sidewalk. Likewise, it was some time before the millions of horses were be rounded up, placed into a giant pit, and shot to death by 20th-century motorists.

However, the industry didn’t really take safety into account until Ralph Nader wrote Unsafe at Any Speed and holding automakers accountable for safety suddenly became fashionable — helping America pass the National Traffic and Motor Vehicle Safety Act in 1966 and subsequent legislation. Granted, vehicular fatality rates still fell dramatically between 1925 and 1965, but the regulatory influence didn’t skyrocket until after Nader’s analysis of the industry.

With autonomous vehicles positioned to change the way we “drive,” the long-established and ever-growing rulebook may need revisions. In July, a collective of automakers, suppliers, engineers, and consumer groups, calling themselves the Coalition for Future Mobility issued a statement urging Congress to consider legislation it deemed “critical to the United States continuing to be a place of innovation and development for the life-saving technologies.” Fast forward to August, and there is already a bill on the table.  (Read More…)

Lane departure alerts and blind spot monitoring systems can significantly reduce crashes if consumers use the features, according to two recent studies by the Insurance Institute for Highway Safety. While this information falls into the no-brainer category, rarely do we get specific metrics on these particular technologies.

“This is the first evidence that lane departure warning is working to prevent crashes of passenger vehicles on U.S. roads,” explained Jessica Cicchino, IIHS vice president for research. “Given the large number of fatal crashes that involve unintentional lane departures, technology aimed at preventing them has the potential to save a lot of lives.” (Read More…)

Back in the days of sky-high tailfins and wraparound windshields, A-pillars weren’t of sufficient thickness to hide little Timmy riding his bike, or maybe that Ford Fairlane approaching from behind that shrub to your left. No, front seat vision was grand — trying to stop your Detroit barge with unassisted drums brakes was the real challenge.

These days, the high-strength steel and airbags needed for rollover and side-impact protection have turned those slim pillars into Corinthian columns capable of hiding a small crowd. A-Pillars are bulky, and that’s a safety problem in itself.

What to do? In Toyota’s case, simply develop a way of seeing through them. (Read More…)

Teen drivers have the highest crash rate of any demographic. Younger drivers are most likely to use their phones while driving or speed in high-traffic areas, and roughly half of all accidents associated with younger drivers were single-vehicle crashes. According to the National Center for Health Statistics, motor-vehicle crashes are the leading cause of death among individuals under 20.

Keeping younger drivers safe is a major concern for institutions like the National Safety Council, but some automakers have their own initiatives. Toyota, for example, had TeenDrive365, which provided a series of online videos aimed at encouraging safer driving habits. While the automaker abandoned that program after 2014, resulting in all of its content mysteriously vanishing, Toyota still seems keen on keeping young motorists on the road and out of the morgue.

However, what’s the best way to encourage responsible driving? Teens don’t like being placated, and they probably know the laws better than older drivers (as they’ve passed their written test far more recently). With this in mind, Toyota thinks humiliation may be the key. The automaker has made mortifying easily embarrassed teens the central theme of its new safety app.  (Read More…)